SERVICES NORTH EAST Paint Booth Service, LLC

How Much does it cost you when your spray/cure booth goes down?

01

MECHANICAL PROBLEMS
 

If we don't have the part on hand, then we know where to get it as fast as possible. So when your mechanical components fail we can replace it and have you back up and running usually within 48 hours of your call to us.

02

ELECTRICAL PROBLEMS
 

Electrical issues can be a nightmare and very dangerous if not taken care of properly.  If your system is acting unusual there are numerous safety controls on every system that is up to code or that we work on thankfully.  Call us if you think you are having an electrical issue with your unit or temperature control, or maybe something isn't quite right that you're used to.  We're here to help with any issue no matter how large or small.

03

MAJOR COMPONENT FAILURES
 

Sometimes things just go boom.  Usually this is caused by a faulty or improperly serviced shaft or motor bearing.  These bearings also fail due to age and excessive operational hours, over time they deteriorate.

This usually makes a lot of noise upon initial failure and then followed by silence, your unit will shut down completely and not be able to start again.  Make sure you know this will not happen to your shop!

04

FILTER MAINTENANCE
 

Intake and Exhaust filters have a life span based on outside dust, dirt, debris, type of paint used, amount of over spray, size of exhaust area and other variables. Know when to change your filters and if you are not sure we can provide you with that information so you can have your filters ready to be installed before it becomes a problem.

05

NEW AIR MAKE-UP UNIT INSTALLATION
 

Whether you want to increase production, upgrade your old unit, or this is the first time you need heat in your spray booth we can help. We are distributors of Mercury (SprayTech) air make-up units because of their raw power, simplistic design and state of the art control system. The only regret for our customers is that they did not call us to get their air make-up unit installed sooner! Just try not to have us install these outside in the middle of winter on a roof that is a sheet of ice, but if you have to we certainly can!

© 2019 by North East Paint Booth Service, LLC.‚Äč